Uponor Sp. z o.o.
ul. Kolejowa 5/7, 01-217 Warszawa
 
Referencja

Uponor pressure pipe system Profuse in Borås town, Borås, Sweden

Uponor pressure pipe system Profuse in Borås town

Fakty o projekcie:

Borås, Sweden
Infrastruktura miejska
Wodociągi
Realizacja: 2010

Zaangażowanie Uponor

2232
When the 250 mm-pipes Profuse replaced old 150 mm-pipes of cast-iron for a two km long distance in Frufällan, municipality will have an important capacity increase for the vitally important water supply. Furthermore the new pipes give less covers and by that less service need and better hygiene.

Background

With the start at beginning of October 2009 a graduation of water pipes is going on Skogsrydsvägen in Frufällan outside Borås. A popular area which needs to be prepared for new houses and increased moving in with higher capacity for the water handling! The road is approx. two km and the work is calculated to be ready in February 2010. The work is ordered by Borås town and it is the Service office which carries out the job. The new pipes come mainly from Uponor.

Solution

The capacity increase is facilitated by the change from the old 150 mm pipes to Uponor’s pressure pipe system Profuse with the diameter 250 mm. Besides a distance of about 500 m where excavating was needed, the new pipes are drawn by pipe cracking. One takes stage by stage, transports poles through the old pipes and fixes the new pipe in the other end. Then the new pipes are pulled back and land right without devastating digging is needed. Pipe cracking is used on the remaining distance for 1,8 km.

“So besides the capacity increase with an increased diameter, you will now have a more hygienic pipe.”

Pipe cracking is a flexible method when new pipes will replace old ones. There will be less disturbances and ground damages. The risks are in crossing pipes and if the pipe should not go deep enough. Then cracks or damages can arise. To minimize the risks the constructors have a good check on all available pipes and they film both before and after the job.

Result

The pressure pipes Profuse replace the old cast iron pipes. So besides the capacity raising with an increased diameter, you will furthermore get a more hygienic pipe. Cast iron has an inclination to put on many coats which risk stopping the flow completely. Such coats cannot come up in a plastic pipe. The new pipes on Skogsrydsvägen can be seen as a first step. “Quite certain more lengths will have new pipes with higher capacity onwards”, Magnus Eriksson, foreman on the Service office Borås town, says.

Uponor pressure pipe system Profuse in Borås town

0001836

Informacje o projekcie

Informacje o projekcie

Adres
Skogsrydsvägen
Kraj
Sweden
Realizacja
2010
Rodzaj projektu
Renowacje
Rodzaj budynku
Infrastruktura miejska

Partnerzy

Partnerzy

End user
Borås Stad

Podobne projekty

Rurociąg tymczasowy dla oczyszczalni Czajka

Rurociąg tymczasowy dla oczyszczalni Czajka

Szybka akcja była bardzo ważna, gdy poważnemu uszkodzeniu uległ kolektor ściekowy w Warszawie, powodując masowy wyciek nieczystości do Wisły. Załoga Uponor Infra pracowała 24 godziny na dobę, aby powstrzymać zanieczyszczenie rzeki. Tymczasowy rurociąg został wyprodukowany, dostarczony i połączony w ciągu zaledwie ośmiu dni.

Retencyjny kanał ściekowy

Retencyjny kanał ściekowy

W Rzeszowie na południu Polski zakończyła się budowa innowacyjnego systemu odprowadzającego wodę opadową, w którym wykorzystano rury i zbiorniki Weholite produkcji Uponor Infra.
Wylot morski

Wylot morski

Wyprowadzenie wód potoków sopockich w głąb Zatoki Gdańskiej to jedna z setek inwestycji proekologicznych zrealizowanych w ostatnich latach w Polsce, w której wykorzystano rury polietylenowe produkcji Uponor Infra.
Inteligentny system retencyjny

Inteligentny system retencyjny

W Rzeszowie, na terenie osiedla Budziwój, gdzie znajduje się fragment terasy zalewowej rzeki Wisłok, we wrześniu 2018 r. rozpoczęła się budowa niemal 26 km kanalizacji deszczowej. Jednym z elementów tego systemu jest retencyjny kanał ściekowy. Realizacja projektu, którego finalizację przewidziano na maj 2020 r., spowoduje, że skończą się kłopoty z związane np. z podtopieniami w tym rejonie Polski.
Renowacja żeliwnego wodociągu

Renowacja żeliwnego wodociągu

Dzięki metodzie ciasnopasowanej możliwa była modernizacja magistrali wodociągowej w centrum Łodzi, na terenie silnie zurbanizowanym w pasach drogowych o dużym natężeniu ruchu pojazdów kołowych i szynowych.

TV-Tower, Estonia

TV-Tower, Estonia

The tallest building in Estonia and the major cultural attraction, the Tallinn TV-Tower, is equipped with Uponor underground ventilation technology.
 New Uponor IQ –Storm water system - Sustainability and Quality in Road Infrastructure

New Uponor IQ –Storm water system - Sustainability and Quality in Road Infrastructure

In December 2011 Central Finland´s ELY –centre (The Centre for Economic Development, Transport and the Environment) started significant road constructing project in Jyväskylä. The aim is to create a new route between highways 18, 9 and 4, which helps reduce traffic jams and smoothes commutation. Uponor was chosen to be one of the suppliers due to our delivery capacity and overall cost efficiency.
New water pipeline

New water pipeline

Uponor Barrier PLUS pipes ensure a safe main water supply in Mikkeli in the old industrial area, where numerous new apartment buildings will be built in the next few years.
Secure tunnel trunk lines

Secure tunnel trunk lines

The safety requirements of the Kamppi-Erottaja-Kruununhaka tunnel built by Helsingin Energia are of the highest level. The contractor Destia selected the former KWH Thermopipe TSC Welding Sleeves for pipe joints. The end result is a pipeline where the insulation and surface material are uniform.

Clean drinking water for 17,000 scouts

Roihu 2016 – the 7th International Finnjamboree organised by Suomen Partiolaiset - Finlands Scouter ry, was held at the Evo campsite in Hämeenlinna on 20–28 July 2016. A camp for 17,100 people was built in a forest area owned by Metsähallitus. Some 3,000 participants arrived from abroad – from about 40 different countries. Uponor delivered 7,600 metres of pipes to the area. The pipes were used to supply clean water and to lead grey water away from the area in a controlled manner.
Weholite limits overflows and pollution in London

Weholite limits overflows and pollution in London

Uponor’s Weholite technology was the key solution in a unique project in London, where the Lee Tunnel and Thames Tideway tunnel have the task of capturing an average of 39 million tonnes of sewage a year from the 35 most polluting combined sewer overflows (CSOs). An upgraded pipeline system was designed to reduce the number of overflows – and their environmental impact – from the sewers and treatment systems serving London. A particular aim is to limit pollution from the sewers and treatment systems connected to the Beckton and Crossness sewage treatment works.

Strong, Safe and Flexible

Skaraborgsvatten in the south of Sweden has replaced its old intake pipeline made of wood with a new one made of Polyethylene. The new system was not only easy and fast to install - it is also impact resistant and capable of withstanding high levels of mechanial stress.
Focus on sustainability

Focus on sustainability

Uponor Infra secure future sewer transport with Weholite. Uponor´s contribution to this complex and prestigious project is not just about supplying Weholite. It also includes project management and technical support such as design and calculations, customized products and field service with onsite installation - all coherently coordinated by Uponor Infra Project Services.
Weholite installed in Valdemarsvik Sweden

Weholite installed in Valdemarsvik Sweden

In 1960, the Fifalla River, which flows through Valdemarsvik into the Valdemars Bay, was culverted. At the end of the 19th century, Lundbergs Läderfabrik was built over the last part of the river at the outlet, but in 1960 a culvert came into place, up to the factory under Storgatan for which the Swedish Transport Administration is responsible.
 
Uponor Vault cleans the storm water

Uponor Vault cleans the storm water

As an industrial city and a port on an inlet of the Baltic Sea, Norrköping in southeastern Sweden strives to prevent pollutants from ending up in waterways. In an ongoing pilot project, pollutants carried by stormwater run-offs will be captured a massive, tailor-made Uponor Vault, a stormwater treatment chamber to ensure that the stormwater is purified before it reaches the Ljura Stream and finally the sea.
 
Flow measurement reveals leaks in the water supply network

Flow measurement reveals leaks in the water supply network

The Water Monitoring Services developed by Uponor Infra enable real-time monitoring of water supply networks – deviations in the network can then be detected and located quickly. Pori, a coastal city in southern Finland, started monitoring an area on the periphery of its water supply network where leaks had caused problems over the years.
Water treatment plant

Water treatment plant

Water company Ylä-Savon Vesi Oy needed a solution to improve the water quality in water supply process. The solution was an aeration tank made of Weholite.
Super-sized cooling

Super-sized cooling

About 1 km of Weholite pipes were installed in Philippines as cooling water intake and outfall pipelines for the Petron Bataan Refinery (PBR).  The Project Service team at Uponor Infra offered a turnkey solutions for the project.
Water supply in very demanding terrain in Norway

Water supply in very demanding terrain in Norway

The global mineral fertiliser, industrial chemicals and environmental products supplier Yara of Norway renewed the water supply to its factory in Glomfjord, close to the Arctic Circle in the north of Norway, with 1.8 kilometres of PE1,000mm pressure pipe. Extremely demanding terrain, limited infrastructure and the most stringent safety requirements demanded exceptional expertise and planning.
ProFuse installed in Borås Stad

ProFuse installed in Borås Stad

When the 250 millimeter pipes ProFuse replaces old 150 millimeter pipes in cast iron on a two-kilometer stretch in Frufällan, society will have a significant increase in capacity for the vital water supply. In addition, the new pipes provide fewer coatings and thus less service needs and better hygiene.
 
Ultra Rib 2 Blue first installation

Ultra Rib 2 Blue first installation

In connection with a project in Sigtuna, the first pipes Ultra Rib 2 Blue are delivered. A new generation of pipes with 70% reduced carbon dioxide emissions. A significant part of the oil for the pipes comes from the waste industry and is vegetable.
 
Sustainable sewer pipeline with Ultra Rib 2 Blue

Sustainable sewer pipeline with Ultra Rib 2 Blue

The Ultra Rib 2 Blue pipes were first launched in Sweden – this year, the pipes have already been installed at several locations. In Finland, a pilot installation was carried out in early autumn in the Jalkaranta district of Lahti, a few kilometres from the city centre.
Unique design ensures controlled stormwater drainage

Unique design ensures controlled stormwater drainage

In Slagelse Municipality, there are requirements for the drainage of rainwater and wastewater to be separated, and therefore it was important that the wastewater solution on the street, Nordre Ringgade, was also updated in accordance with current legislation. The client has received an approved solution where the wastewater from the commercial property in no. 59 has been separated from the rainwater. The rainwater is now diverted directly from the 2,500 m2 car park.
Safe water supply for an old shipyard and sawmill area

Safe water supply for an old shipyard and sawmill area

The Pateniemi waterfront area in Oulu, Northern Finland played a role in the history of Finnish industrialisation. In the mid-19th century, its shipyard built large merchant vessels, and later it was the location of one of the largest sawmills of its time. Now, the waterfront is entering a new era with the completion of a residential area for 2,500 inhabitants. Uponor Barrier PLUS pipes – which are both durable and non-permeable – ensure a safe supply of potable water in this area that was in industrial use for over 100 years.
Reservoir tank for unordinary village of Tuuri

Reservoir tank for unordinary village of Tuuri

In an ordinary village with less than 1,000 residents, a reservoir tank would normally be unnecessary, but Tuuri in Southern Ostrobothnia in Western Finland is not an ordinary village. The village tourist attraction draws visitors up to six million visitors annually. This needs special solution for potable water delivery.
Uponor filter chamber part of the stormwater study

Uponor filter chamber part of the stormwater study

In recent years, stormwater quality management has become an increasingly important part of urban stormwater strategies. A pilot project was launched in Heinola to clean stormwater with innovative filter chambers developed by Uponor. At the same time, valuable research data will be collected on stormwater quality from two different types of areas and on the treatment results achieved with filter chambers.
Espoo's Itäranta is being renovated sustainably

Espoo's Itäranta is being renovated sustainably

HSY (Helsinki Region Environmental Services HSY) is testing a new kind of area renovation operating model in Itäranta, Espoo, where the aim is to get the area's water supply network in order once and for all. New steps are also being taken towards more sustainable construction: the selected Uponor Blue pipes utilising renewable raw materials will reduce the carbon footprint of pipeline installations by 70% compared to traditional plastic pipes.
Uponor Vortex stormwater solution

Uponor Vortex stormwater solution

The City of Espoo is the first in Finland to introduce the Vortex stormwater separation chamber. It can be used to efficiently separate floating and descending solids from stormwater. The aim is to reduce the maintenance costs of the retention system built from stormwater tunnels and prevent solids from ending up in waterbodies.
Uponor-filterbrønde en del af regnvandsundersøgelsen

Uponor-filterbrønde en del af regnvandsundersøgelsen

I de senere år er kvalitetsstyring af regnvand blevet en stadig vigtigere del af byernes regnvandsstrategier. Et pilotprojekt blev lanceret i Heinola for at rense regnvand med innovative filterbrønde udviklet af Uponor. Samtidig vil der blive indsamlet værdifulde forskningsdata om regnvandskvaliteten fra to forskellige typer områder og om de rensningsresultater, der opnås med filterbrønde.